Winegrowers Supplies  -  Jam cooking pots - steam controlled - all with double wall

It’s the only indirect steam cooking system with automatic temperature control. No part of the pot ever registers a temperature over 105 °C, avoiding the danger of carbonisation or partial combustion of food. And thanks to the indirect use of steam, no valuable substances are ever lost. The whole flavour and prime nutrients remain intact.

The secret of the operation lies in the original, patented system with which they are made. There is a cavity for water between the two walls of the pot.

When the pot is put on the stove, the flame heats the outside bottom, bringing the water contained in the cavity to boiling. The water, when it boils, produce steam, which in turns heats the inside wall of the pot where the food to be cooked is contained. Hence the food does not cook in direct contact with the flame, but only with the steam heat, kept constant at 105 °C by the special control valve. With any flame, whether high or low, with or without lid, the internal temperature will always remain at the ideal level to cook any type of food.

The gravity regulated valve keeps a constant temperatures inside the pot. With its hiss it disperses all excess steam and signals that we should turn down the temperature of the stove with obvious saving of energy.


   

  8 litres, 237 Euros
  in a carton 45 x 35 x 35 cm, weighing 5 kilos with packing.

 18 litres, 406 Euros

 These pots cannot be tipped for pouring out. You need to use a jug or ladle to remove the jam.


  

with 1" outlet valve, for dispensing the jam:-

 18 litres, 30 cm diameter, 6.3 kilos, 645 Euros

 26 litres, 40 cm diameter, 920 Euros

 40 litres, 40 cm diameter, 1024 Euros

 

Professional models with electric heater, it’s much easier to have electric power rather than gas, especially for the installation:-

stainless steel (AISI 304) double wall with high quality glycerine filling, viewing glass for glycerine level, glycerine refill and safety overpressure tube.
Direct heating from the oil bath via electric screw-type tubular heater made of stainless steel with thermostat, adustable temperature setting from 50 to 200 °C, 5/4" outlet for jam, now on 3 castors with reinforced bottom.

150 litres capacity, 660 mm diameter x 860 mm high (internally 600 mm diameter x 530 mm high), 118 kilos, 9 kWatt, 3-phase 380 Volts, 3 metre cable, 3140 Euros

Free standing Mixer/stirrer for use with the electric cooking pot, 15 revolutions/minute, 1490 Euros

You can stand the pot on a stainless steel table, so it is at a comfortable height for the person using it.


or 300 litres capacity, with Mixer/stirrer: 10,996 Euros

       

With butterfly-valve DIN65 on outlet for quick emptying.
Plug-in version with 3 metre long connecting cable and 16 Amp plug, 3-phase 380 Volts, 2 x 12 kWatt

The stirrer guarantees a high degree of autonomy during the cooking process.
The rotation is electronically adjustable from the control panel.
The stirrer has scrapers on the bottom and on the container wall and can be removed for cleaning.

While heating up it’s better to keep the lid closed most of the time. The lid can be opened to look at the product.
It's not a pressure cooker, steam is released outside.
There is a thermostat that controls the temperature of the glycerine. To measure the temperature of the product we recommend using a digital thermometer with remote probe.
The valve is quite near the bottom in order to get as much product as possible out through the valve.
For large production or especially when filling small jars we recommend combining it with a small volumetric filler.
There is no insulation around the pot, you can make a wire protective cage, so the operator can't accidentally touch it; for Health & Safety reasons.


  

Professional models with 14 kWatt gas heater built in:-
    the gas heater has a safety valve and lighter.

For the gas heater a sealed single-wall flue is necessary so the fumes from the burner are extracted,
diameter 150 mm. We don’t supply the flue pipe.

     Included is a 0.18 kWatt 230 Volt stirrer/mixer.

        73 litres capacity, 2960 Euros

      115 litres capacity, 3384 Euros

               Weighs 80 kilos, 100 x 100 x 125 cm !

      230 litres capacity, 4679 Euros

      330 litres capacity, 5279 Euros

      390 litres capacity, 5875 Euros

Prices shown are exclusive of Vat.
Delivery will need to be charged at cost.

www.winegrowers.info